Articles & photos

Back

28-8-2014 Xb12X Big service, XB12 modifications.

29-8-2014 - Buell Xb12X big maintenance ,not running nice. Buell XB12 modifications and titanium header.

Buell Xb12X big maintenance ,not running nice , customer from Germany with a buetiful Uly.

 

Buell Xb12X big maintenance, down side translucent covers they crack really easy.

 

Buell Xb12X big maintenance, warming up for oil drain.

 

Buell Xb12X big maintenance, gearbox plug , some debris is acceptable.

 

Buell Xb12X big maintenance, engine oil no debris is good.

 

Buell Xb12X big maintenance, gear box oil back to level.

 

Buell Xb12X big maintenance, oil filter primed and ready to go on.

 

Buell Xb12X big maintenance, filling the engine oil.

 

Buell Xb12X big maintenance, little trick with the clutch mechanise hook it on out side the cover.

 

Buell Xb12X big maintenance, and adjust.

 

Buell Xb12X big maintenance, sloppy primairy chain ( customer noted the bad to neutral shifting ) adjust to specs.

 

Buell Xb12X big maintenance, has been some little stones on the belt, is still ok, but need to keep a eye out, some ware visible.

 

Buell Xb12X big maintenance, i like it when the axles are greased up when i pull theme out.

 

Buell Xb12X big maintenance, they look good, but turning by hand... they feel gritty ... better put new ones in.

 

Buell Xb12X big maintenance, new bearings and ready to go back in.

 

Buell Xb12X big maintenance, chin spoiler screws... loctite.

 

Buell Xb12X big maintenance, spark plug where recently replaced, i gap theme correctly and a little neverseas and they will e good to go.

 

Buell Xb12X big maintenance, battery connections check for tightness.

 

Buell Xb12X big maintenance, customer also put in a new K&n filter recently.

 

Buell Xb12X big maintenance, check the rear plug to , regap and neverseas.

 

Buell Xb12X big maintenance, temperature cable has been rubbing.. will route it differently.

 

Buell Xb12X big maintenance, rough running, off the scale AFV , Manus bike ? check the fuel pressure..not the first one with a bad pressure regulator.

 

Buell Xb12X big maintenance, way to much fuel pressure running, need to contact the customer.

 

Buell Xb12X big maintenance, first continue with the service, front end.

 

Buell Xb12X big maintenance, front bearings, did also feel gritty , new ones already in.

 

Buell Xb12X big maintenance, fork oil change, clean the legs , the lower ends the seals will slide over this dirt.

 

Buell Xb12X big maintenance, protect the cap ans zero the rebound adjusters.

 

Buell Xb12X big maintenance, forks back in.

 

Buell Xb12X big maintenance, loctite on the brake calliper screws.

 

Buell Xb12X big maintenance, these little screws can be a bitch.

 

Buell Xb12X big maintenance, little never seas on the screw for the next time.

 

Buell Xb12X big maintenance, and don't forget the change the rear brake fluid.

 

xb12 mods, starting up the first time, i love the way the titanium colours.

 

xb12 mods, old model belt guard, please use neverseas on the screws.

 

xb12 mods, chin spoiler back on, a little tight.

 

xb12 mods, easy job to make some clearance.

 

xb12 mods, yeah... no will not mount this back.

 

xb12 mods, and remove the cable completely , with our tune 2003-2007 this one is disabled anyway.

 

xb12 mods, front brake pads... will replace this knackered bolt.

 

xb12 mods, little trick, can change the pads with wheel in place.

 

xb12 mods, new pads in.

 

xb12 mods, last checks , new handle bar check if the switches don't tough the cover.

 

xb12 mods, test ride  nice all i can say , customer will love it , has become a complete other bike.