Articles & photos

Back

14-5-2014 Buell Xb12Xt, X1, Xb9S, Xb12SX.

9-5-2015 - Buell Xb12Xt big service. Buell X1, running bad. Buell Xb9S, check up. Buell Xb12SX 2010, rear rocker cover gasket leaking.

 Buell Xb12Xt big service,

 

Buell Xb12Xt big service, these batteries come with 2 spacers , but i see allot off people don't use theme , the battery poles will not be good on.

 

Buell Xb12Xt big service, i not needed to use some washers , it will work, but the special spacer delivered with the battery work better.

 

Buell Xb12Xt big service, drain oil and take off the plastics for inspection.

 

Buell Xb12Xt big service, cold weather daily driver looking at the mayo off the clutch cover.

 

Buell Xb12Xt big service, gearbox oil back in and adjusting the clutch mechanisme.

 

Buell Xb12Xt big service, cover cleaned, ready to go on.

 

Buell Xb12Xt big service, front spark plug change from below.

 

Buell Xb12Xt big service, all ways check the cable "clicks " on the plug.

 

Buell Xb12Xt big service, rear brake pads need to be changed.

 

Buell Xb12Xt big service, belt inspection, still okish... starts to crack a little, not really bad yet.

 

Buell Xb12Xt big service, last time the bearing where changed was 22000 km ago, as this is a daily driver, and there where feeling not really nice anymore, we replace these.

 

Buell Xb12Xt big service, new bearings in.

 

Buell Xb12Xt big service, and new pads on.

 

Buell Xb12Xt big service, change brake fluid.

 

Buell Xb12Xt big service, little oil in the airbox cover is normal, we will clean this.

 

Buell Xb12Xt big service, the hidden rear spark plug,

 

Buell Xb12Xt big service, use a piece off hose to start the rear plug to prevent cross threating.

 

Buell Xb12Xt big service, air box clean, airfilter cleaned and charged agian, is good for a other 16000 km.

 

Buell Xb12Xt big service, front end out to check bearings and change oil.

 

Buell Xb12Xt big service, missing valve cap, better put one on.

 

Buell Xb12Xt big service,, front wheel bearings still felt ok, brake pads would not have lasted to the next service, we replace these.

 

Buell Xb12Xt big service, brake cylinder screw was a little stubborn, needed to drill the head off, to releave the tension, after that you can crew it out with your fingers, oil lever check and test ride.

 

Buell X1, running bad.. replacing the intake seals did help a little, but still it was running on 1 1/2 cylinders , fuel pressure test.

 

Buell X1, running bad, fuel pressure ok,

 

Buell X1, running bad, compression test, also ok same reading front and rear.

 

Buell X1, running bad, off course we tested the rear spark plug, but still no change, injectors where suspected, after pulling these out, the problem became more obvious.

 

Buell X1, running bad, with bad running problems, smart to test the injectors on flow, you see here the rear one on the left !!! hugde differance.

 

Buell X1, running bad, cleaning ultrasonic.

 

Buell X1, running bad, flow test 2, still some difference but it is improving, a other cleaning cycle to see if it will help.

 

Buell X1, running bad, flow test 3 , still getting better, after cleaning cycle 3 , the difference was little enough to mount theme back.

 

Buell X1, running bad, injectors back in, and bike was running good again.

 

Buell Xb9S, check up , customer has just bought this bike, and wanted us to check here out.

 

Buell Xb9S, check up , customer has just bought this bike, and wanted us to check here out , check bearings, belt, brakes, bike is in good condition, intake seals leaking and neutral switch not working.

 

Buell Xb9S, check up, ready to rotate the engine for intake seals.

 

Buell Xb9S, check up, we will fix the leaking clutch cable to, and put some heat shrink tubing with glue over this.

 

Buell Xb9S, check up, intake seals replacing.

 

Buell Xb9S, check up, neutral switch not working.

 

Buell Xb9S, check up, after replacing we got a reading 

 

 

Buell Xb9S, check up, will change the bolts to for the battery tray.

 

Buell Xb9S, check up, battery tray will not vibrate so much like this.

 

Buell Xb12SX 2010, rear rocker cover gasket leaking.

 

Buell Xb12SX 2010, rear rocker cover gasket leaking, rotating the engine and replacing the gaskets.

 

Buell Xb12SX 2010, rear rocker cover gasket leaking, cover off , still old orange gaskets, we will put some new better black ones in.

 

Buell Xb12SX 2010, but was also here for damage repair, new header and exhaust on, coated black.

 

Buell Xb12SX 2010, nice