Articles & photos

Back

26-7-2017 X1 finish, XB tires, XB gasket, 1125

29-8-2017 - 26-7-2017 Buell X1 finishing, Buell Xb tires, Buell XB head gasket, Buell 1125 charging

x1 run in and tuned on the dyno.. now making her ready for the road — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

mount the original airbox...lets be friendly, there are better systems ;-) — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

plastic tube back on.. and suport ring — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

intake air sensor — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

smart customer made some springs to hold the airfilter — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

covers back on and she is ready to go home — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

tire job.. new tires needed for the upcomming training — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

bearings checked, belt checked, and new rubber on— bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

tighten the axle to tq and don't forget the pinch bolt— bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

front the same loose the pinch bolts — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

and get the wheel out — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

that was allot off weight !! — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

new tyre.. could do with the half — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

front axle to 55 Nm — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

and caliper bolts 50NM and a drop off loctite — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

bump the front suspention a few times.. to set the front forks — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

and tighten the pich bolts — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

engine was making sounds like a steam engine.. head gasket blown away — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

the ends off the gasket was scraping the pushrod cover — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

yep... missing a piece — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

bugger.. stud pulled out ... lost the tension on the head bolts and blow the gasket out — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

taking care no debris can fall in the case and drilling and tapping OS timesert — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

timesert mounted... good — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

stud back in and tq the stud — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

but the loose studs distorted the cylinder.. and the new rings where scaring .. i will send these cylinder off to check and rehone, mounting like this will give problems — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

German 1125 not charging — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

little diagose .. non off the stator leads are short to ground — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

ok.. running volts AC check.. put your meter on AC , engine running.. one lead pair 18.5 Vac idle.. good— bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

the other pair only 3,9 Vac ... ok clear case off stator bruned out — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

the customer told me this was repaired before, but did not know how.. so opening up — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

yes has been repaired before , the cut the wires .. so they did not have to pull these through :-( — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

cover screw missing a copper washer.. — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

cover off.. the nice smell off burned isolation material ... — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

i pull the wires out .. — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

stator has not been modified with oil jet.. very little use to put only a new stator in.. as it will burn out way to soon.. — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

rotor removed, we send this off to edm the oiljet inside, as we take use off the existing oil chanel in the crank.. — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

sprak outer cleaning and clean the threads — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

oil the sprag clutch to prevent it from wear — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.

inside stator... will first contact the customer to make a repair plan — bij Twin Motorcycles Buell Support forever.

foto van Twin Motorcycles Buell Support forever.